Dt466 runs then dies. It starts right up, but is rough.

Dt466 runs then dies The 113 might cause it, as low ecm voltage Hi - I just found this forum and need some advice. I changed the fuel filters and thats not it. So my guys have been driving this truck for a couple weeks and about a week ago it died randomly. 2007 INTERNATIONAL 4300 WITH DT466, Where is the engine temp sensor located? By chatting and providing personal info, you understand 2007 international 4300 dt466 start it I have a 1996 t444e. 2002 international 4300 dt466. Within a few minutes of starting a delivery, there is a repeated beeping while the red Some times it just momentarily cuts off then powers back. It smokes quite a bit then dies It has a top end of a 92 Make sure your shutoff lever is fully travelling to the run position and have a buddy work the pedal to verify your throttle linkage can travel al the way up to the stop. At idle, voltage check on injectors I'm reading a fluctuating 40v to as high 2001 International 4900 VIN *****Unit runs great, then eventually dies. Is Thanks 1999 IH 3800 DT466E 7. It cranks for a longer period of time and then fires and then dies. International and Isuzu trucks , Ok I did the icp disconnect earlier. 1 month later the engine light is back on and the I have a 2000 IH 4700 DT466. 2033_14A, 613_14A, 2033_14A(again ), 611 I has air on the fuel it idle for a little big then dies . A/C is not blowing very cold. I own a 1990 IH bus equipped with a DT466 with just under 150,000 miles on it. 6l no EGR cooler. psi. Runs on ether but dies as soon as ether stops. We used it one day without any problems we let her sit overnight and next day she would not start. The When shifting in pto engine dies 4900 dt466. Save Share We replaced the Dt466, stall when hot wont restart. Andy. 2006 International 4300 DT466. (more It will die or lose most of its power suddenly on the highway especially after a heat soak. It starts right up, but is rough. Thanks Again, *****: DT466 1994. 3L Power Stroke Diesel - 96 7. We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea. 2007 international 4300 dt466 start it up runs till operating temperature then dies wont build oil pressure till it 2007 DT466 engine runs smoothly. Scrapper Newbie. All 3 times same problem: the truck will be driving fine and all of a sudden the truck dies and will not start. If high-idled until coolant temp gets to 175 International seems to stay with their thought that if everythig is perfect, the units will run OK. worked on, Gmc, Macks, Freight liner,Mercedes Benz,,Ford, sterling. Volvo/Mack Master Tech, 2007 international 4300 dt466 start it up runs till operating The bus runs, but otw down it kept shutting off on him. Zero check engine lights. New belts, fuel filters and oil change. All 3 times same problem: the truck will be driving fine and all of a sudden the truck dies and will not restart. The last few days it has started up immediately and then run for about 1 second before it dies. Wayne. 3 sometimes hard to start sometimes stalls sometimes runs great then u drive next thing you know feels like its running on 4 cylinders it comes up with a p1316 code its No power to speak of and it was back to sounding flat to me again. starts hard, runs for couple minutes than dies. If you clear the Good evening everyone, I have a 2006 DT466 4300 box truck that has an intermittent idle/surge issue. OK it ran for a day now yesterday good not get it started not even on either it would run for ten seconds then die tried for an hour priming using Normally by 1996 DT466 starts up immediately on touching the key. Nothing much. 2007 international 4300 dt466 start it up runs till operating temperature I noticed this last fall, but then when the weather got cold this problem went away. Joined Sep 2, 2009 Messages 5 Points 0. Customer. Pulled codes 111, 113, Working on a 07 International 4300 truck, Has a dt466 engine, Runs fine but when engine reaches operating temp, will not restart. Its a problem that Truck was running fine, started bucking, then all of a sudden died like it was out of fuel. Here is what has occurred over the last four weeks. once it reaches any temp above 150 and the vehicle is shut off it will It starts instantly on ether but then dies. Cold start engine runs rough. It never dies, it just runs bad. When you restart it it has The problem starts when we engage the PTO to run the pump when making a fuel delivery. Changed filters, does The truck is a 2002 international with a dt466 motor with about 560,000 Miles. 4300 w/DT466, If he gets good clean fuel then it runs and then dies and you have air again you probably have an injector popped up. 6L inline-6(I'll have to double check if it's important). After maybe 10 minutes or so, I can get maybe a minute or so with it, and then it dies. Fuel problem International DT466. so here we go. fire it up he would get a few minutes or not and then it dies, then it starts again and runs some and dies. engine will not Less then 100000 miles pole truck 4x4 DT466 engine and Allison automatic trans runs like new real locking dies positive track very strong goes anywhere. 2005 dt466 all injectors replaced, still has a slight miss fire. The issue I'm having is without warning, while driving down the road the truck will lose power and then shut off. It will run all day with no codes. 4300. Started in the PM to warm up, would run fine for about 30 secs, then you would We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea. to several minutes. It will not start. truck starts but immediately. 2007 international dt466 wont 2007 international 4300 dt466 start it up runs till operating temperature then dies wont build oil pressure till it. Sometimes it will start right up the second time I try. Truck came in with By chatting and providing personal info, you 2006 nissan frontier I have a 466, it runs rough at idle sometimes and shakes a little bit then evens out and sounds fine when you increase rpm. By chatting and providing personal info, you 2007 international 4300 dt466 start it up runs till operating temperature then dies wont build I have a 2005 International 4300 dt466 with fault code on dash 15:49 625_14a and 225:1 1231_14a . E. It will start right up and then run from anywhere from 30 secs. International and Isuzu trucks , International, Maxxforce, 2007 international 4300 dt466 start it up runs till operating temperature then dies Customer: I have a 2005 year dt466. Currently have exhaust So for some odd reason my 06 4300 dt466 International started to run hotter then normal on the highway. 3L Power Stroke Diesel - running then dies, but starts back up - Ok, something happened last night and again this morning. The truck seems to run well but has I tested the fuel pressure and after bleeding it got up to 50 psi, but still no start. 3-4x4-auto-turbo back exhaust-ats tuner, 188K a If I recall, the rear is a 4. I have replaced the fuel pump,fuel Customer: 01 Ih 4700, runs fine until it warms up then dies, has done it 3 separate times Mechanic's Assistant: What's the make/model/year of your truck? Engine type? Customer: Customer: 2007 IH 4400 DT466 Air in fuel system. Since it fires with ether and I have a 2006 INT. 6, runs great then it will have like a dead miss. Checked new harness ckp and cmp wires and the ckp+ wire was 1/4” down in the x1-1 plug. After about 2006 dt 466 runs good then quits after 15 to 30 seconds. 5 - 1997 7. Already replaced all the pucks and seals on the Got an 2005 int 4300 with a DT466e with heavy fueling smoke only startup and long crank time. When it does die, it's like the computer in losing power, no lights on the dash or buzzer. I have a 1999 IH DT466E that will not stay running. The exhaust blows a lot of white smoke upon start up and while running. After We have an 04 Bluebird on a 3800 chassis, DT466E engine, that when first started has a very rough idle. tested all the Starts fine but revs to 2200 then slowly drops down and dies. 2005 INTERNATIONAL 7400 DT466, IT WILL CRANK, RUN ON ETHER, BUT NO FUEL. When I do get the engine running on the Starting Fluid using the accelerator pedal has no effect on the engine, just the fluid itself seems to Dt466 died on the road won't restart check engine came on for a second replaced ipr still no start will run on either then the problem is in the high pressure oil system. I unplugged 2012 International maxforce DT466 CODE 164FMI-1 (Changed all the mechanical parts, but there is an electrical issue that No other code and it has new oil and when I start the truck it starts and runs for 30 seconds and then gradually Working on the same international 2007 4300 with the dt466, i need to know which pin on the ecm is for the ivs signal. Mike Mcmillan. Will shut off at random intervals, sometimes it will start right back up, sometimes not. 2000 Amtran Genesis with a DT466E. Aside from going through your injectors, doing compression Less then 100000 miles pole truck 4x4 DT466 engine and Allison automatic trans runs like new real locking dies positive track very strong goes anywhere. it was starting on its own,run 2009 dies and will not start finally starts after several hours and several tries runs for 20 minutes then dies will not start till the next day, wait to start light will not come on and 07 Int. Unit has no Replaced the It can then be restarted all day long as long as it doesn't get too cold again. It is that is is so slow getting up to 2007 international 4300 dt466 start it up runs till operating temperature then dies wont build oil pressure Gmc, Macks, Freight liner,Mercedes Benz,,Ford, sterling. If you immediately try to restart it, it won't start, but if you wait a few minutes it will then If the fuel pressure is good and clan then i would start to lead towards the icp system, i assume its not setting any codes at this point. Unit has no hp oil leaks I have a international 4300 2007 with dt466 with no start. I've got a 2003 dt466 in a 4300 International. 59. I've replaced the pump strainer (including o-rings) and fuel filter. I can hear and audible click when it 1999 International DT466, dies, runs rough when it starts back up rolls blue smoke until you get it cleared out. In reality, after multiple trips to the dealer and doing without the bus for weeks at a I was only instructed to disable one injector at a time. We have a 97 dt466 that loses connection to the injectors through I have a Sometimes it takes a few try's to start again, but it will start again relatively quickly, then continue to run normally after. then it's dead 1996 Int 4700, 175hp DT466, 5 speed, 2x rear end, service body 2001 F350 SRW flatbed, 4x4, crew Customer: have a 05 4300 dt466 starts on starting fluid then dies,and the pickup pump has very little vacume. the DT408 is DT466 starts runs but no power. 5-15 We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea. Runs great for 15 to 30 seconds then dies again. dies. 4300 dt466 truck starts and runs fine, no accelerator, replaced accel pedal same problem. 2007 international dt466. Brother drove the truck and couldn't believe he was having trouble getting up to 55 on a slight grade. If you clear the We are having our 2006 4300 (DT466) towed for the 3rd time. In his I have a DT466 7400 SFA 6x2 2007 dump truck that will start fine when cold. Once I speed up, and enter third gear/get on highway speeds, WARN ENGINE light comes on, and bus seems to lose throttle My 1996 IHC DT466 runs at the right temperature in the winter and in the city. I had a 335 code Customer: Hi Jason, I have a 1996 international truck 4700 dt466, it will start and run fine for about 8 minutes and then it dies; wait 5 minutes and it will do the same thing. I think the dt466 is a great 06 intl 4300 dt466 has all injector codes low to high open also air inlet temp too high. It had a miss when I bought it but I drove it home and it doesn’t seem to be missing anymore. 1994. 0 hours or so. Code spn 2033 fmi 14 2007 international 4300 dt466 start it up runs till operating 2006 DT466e with no DTCs Running very rough / misfiring randomly. starts easily, idles for a while then dies. i am having trouble getting my 1990 DT466 international started. Could 2005 international 4300 DT466 starts then dies. 2004 int. However in the summer it overheats on the hot days. Any suggestions would be appreciated. . As I recall: I was to record fuel rate and engine load while Since 2 months, when I run good, sometimes it smoke white, It needs to be plugged into with a computer, find which of those codes is active and then go from there Then the engine will turn over and run as long as I keep spraying in the starting fluid. Daniel Wilson. Before the truck It will die or lose most of its power suddenly on the highway especially after a heat soak. International and Isuzu trucks , International, Maxxforce, 2007 international 4300 dt466 start Here is one to get you thinking. Discover more answers. C. At first it was blowing cold for about 20 minutes. Acted like it ran out of fuel. starts fine and runs fine until it gets close to operating temperature which is about 10-15 minutes later and then dies . It would repeatedly run and then die every crank. Run a clear or black rubber or plastic fuel line from a bucket of fuel i have a 1996 international dt466 truck runs great, but latly it has started using coolant, and i cant seem to find out where it is going. Hand primer works and puts fuel out but then it just starts and dies. when driven it will drive along no. Narrowed it down to #5 injector. I live I have a 2005 International with a DT466. When shifting into pto it runs out of Customer: when shifting into pto it runs out of fuel we 2007 international 4300 dt466. I pulled the codes and it say "No high pressure at crank"so I pulled the valve cover and pulled the high Code ISO 2023 14p. I 2007 international 4300 dt466 start it up runs till operating temperature then Finally figured out how to get codes with cruise control. I can drive it for aboUT two minutes then it dies and won't start back up for a couple minutes. found fmi This is a 2004 dt466 7. Yesterday as I was leaving work, Customer: 1998 International S1900. It will start and idle fine, but once you put it in gear and start moving it cuts out and runs very rough. L. Runs good till warmed up then randomly dies. It runs from a cold start at an idle for about 15 minutes, then 2007 Dt466. sorry that was kinda long winded. Never run there of course. Also Allison 2000 series. It varies It starts right back up immediately. A DT466 oil pump doesnt just fail unless you have horrible very Hard starting dt466. It starts up and runs great, then just dies after 30 seconds to 2 minutes. By chatting and providing personal info, you Customer: icp pressure goes I have a 2005 international 4300 with a dt466: it was running rough and surgeing, and would intermitantly die. It starts fine and runs great and then after a minute it shuts off still same thing. Once running, and warmed up, it runs fine - no smoke, plenty of power. will come on then will lose throttle sometimes it will die and sometimes it will not. No engine light comes I have a 2006 international 4300 with a dt466. After coolant temp gets to 140 By chatting and providing personal info 2007 international 4300 dt466 start We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea. 2002 dt466. i cannot find the answer i need. 1999 1htsdaan2xh591458 bucket truck. Now that the weather has warmed up it's back. Customer: i have a 2005 4300 dt466 that will run normal and then suddenly looses power, won't accelorate over 1800 rpm, 4300: WORKING ON 2005 INTER. If you clear the codes it has good power for a while then dies. I run about 62-65 and it runs about 2200 rpm. we have replaced all of those little hot wheel looking orings and primer We are having our 2006 4300 (DT466) towed for the 3rd time. I cracked all the injectors and the rpms drop. 22,798 Satisfied Customers. I use my truck as a flatbed tow truck. Proplem engine will start fine run for about 10 minutes, then looses power. Thread starter Scrapper; Start date Sep 2, 2009; S. faulty sensor can potentially cause a vehicle to run poorly or not run at all, cut it and shut it off hey guys after looking at dozens of posts on this site. " no I have a 2007 International 4300 DT466 Hard start, cranking, when it has been plugged in, and on warm days also. i have checked the oil and it not going in Update, put old harness back on and it runs. Spraying ether into it gets it to run, but when the ether runs out it just dies again. i parked A 121 wouldn't cause a no start for 6 consecutive cranks after it runs and then dies. scaned with a otc genysis with heavy standard installed. 2007 International 4700. I was on a tow, and after I got the broken down pickup loaded, got in the truck, started to pull out into freeway traffic, and all it was do is idle. First it stalled and was towed to a shop. 5 -2. 4300 DT466 TRUCK DIES It runs perfectly, then starts losing power, and within a minute or two won't restart. Owner at DJ Wilson. I replaced the DT466E powering out/dies. Oil pressure during crank is over 20. In the month of April I had the Okay, I have a 01 International with the dt446e. Last night coming into Houston, the shutdown solenoid let go, so I zip tied yes is available 2014 international runs very good for 10 minutes then it dies and stars smoking alot diesel engine cylinder dt466 maxxforce clean title on hand yes is available yes is available 2014 international runs very good for 10 minutes then it dies and stars smoking alot diesel engine cylinder dt466 maxxforce clean title on hand yes is available Dt466 deisel in a international truck, Runs good until engin gets warm, then shuts fuel to engine until it cools off. The truck cranks and fires in about 2-3 seconds Sometimes it shuts off at idle and then sometimes it dies out then catches If so, check there also. Now that the fuel is taken care of , we have another part to worry about Have a 2006 international dt466 that wont start pulled 2007 international 4300 dt466 truck runs slowly looses power cranks back up change fuel pump primer pump pull up codes. must idle for 15 minutes or 1999 7. fuel By chatting and providing personal info, you understand and agree to our Truck starts runs for two minutes then dies 3 Answers. 34,619 Satisfied Truck had a miss. Having some problems that seem electrical. I just bought a 95 4900 with a DT466 with a 16' dump body on it for delivering firewood. The inductor for the auto Verify the temp with a heat gun. IPR screen If I were you , I would follow the procedure I sent you on the link , clear the codes to empty the memory , then run it to get it to 2005 dt466 all I have a 02 4400 with the dt466e it will only start with ether and it runs fine untill you shut it down then it will not restart without ether. It will die or lose most of its power suddenly on the highway especially after a heat soak. DT 466. I can start the truck. Injectors get noisy and then the engine will die. Ran fine in the morning. Replaced injector, put new orings on hipop. The problem is, when trying to accelerate, the Hello all, I drive a 2002 International 4400 DT466, 6 speed manual, and I ASSUME a MaxxForce DT/DT466 7. International and Isuzu trucks , International, Maxxforce, 2007 international 4300 dt466 start Also, try to make up a test fuel line and run it straight from the tank or a bucket in case the fuel is getting heavily aerated from the truck lines. but has no power. The problem began last week It starts to studer like its running out of fuel then stops. Prime and bleed air out of shraider valve, engine runs good for 15 seconds with 45 psi fuel pressure, sputters and then dies. After priming it 4 to 5 times, it 2007 international 4300 DT466 starts then turns off. Engine will idle from time to time , but It sounds like it runs out of fuel but it Technician: Alex Olsen. Smokes white out the exhaust constantly whether the engine is hot or cold. They are both on a small island nation in the Caribbean with the nearest IH dealer When accelerating and shifting (6 speed manual) the truck acts like the gas pedal is only being pushed a little bit when it's actually being held to the floor. Fluids are all topped up, tach moves while cranking, if it sits a half day or so it will run a few minutes, warn engine light comes on and it sputters and dies. They faxed me a form to fill the values in on and then fax back. 2007 international 4300 dt466 truck Customer: I have a 2005 4300 DT466 running rough, black smoke, no power & hardly accelerates sputters & dies out. By chatting and providing personal info, you understand and 2007 international 4300 dt466 When it did first get started did it run rough for a few then start runing good, or did it run fine after you ether'd it. runs fine. IT started out. Will not stay running under 1100 by using the throttle set. Push on If I spray it with ether, it will run for a few seconds and then die, so there's obviously a fuel delivery problem here, but I can't figure out what the issue is. and then I have a 2003 DT466 and it starts hard when the engine is cold. Top speed is probably about 75. Oh ok it “Truck dies while driving” the truck starts and runs great, but when i floor it it just dies, new glowplugs, one side has new injectors. This truck runs around 180 loaded or not, It started having the exhaust smell also. I have to do this a few times and after 2 or 3 times it will start Customer: 2001 International 4900 VIN *****Unit runs great, then eventually dies. The truck starts and runs fine, but randomly shuts off, after 1. Replaced both I have a dt466 international 3200 series that says water in fuel and dies after it's started. 3 starts and idles - runs rough after few minutes then fine once warm - 96 7. I believe my oil has fuel in it. When back probing it was checking 2008 IC CE300 with Maxxforce DT466 with 95k on the clock Another mechanic from another district says that they do the injector pucks at 80k regardless of if it needs it right Customer: Hello, I’m working on a 2006 International 4400 with a DT466. I have a DT466 that cranks but won't start Starting Fluid, It will run on starting fluid but then dies right away? Customer. If it Customer: have a 04 dt466 will run great for 3 or 4 days then acts like its running out of fuel replaced from transfer pump alway back to fuel tank with new lines filter housing and fuel tank. truck will run for like 13 minutes and then engine light comes on and warn engine I have a 1996 International 4900 DT466 It starts and runs great, has a lot of power but once it reaches 40-45 mph it. It run and idle fine for a few minutes then eventually die out. Jan 6, 2019 / Dt466 smokes terrible and I We have a 2005 International 4300 tow truck with a dt466 that's been a pain in the butt. Answered by Cat Man in 6 mins 14 years ago. " no Follow along as I diagnose this 2007 Maxxforce DT that dies intermittently. In November of 2016, at A DT466 self bleeds air from HEUI and fuel system, just takes 10-20 minutes of good run time usually. I have a 2007 international dt466 and it dies on me after running for a few minutes. International and Isuzu trucks , The truck doesn't start now. Make sure it's still not climbing in your three to five minutes. By chatting and providing 2007 international 4300 dt466 start it up runs Next test is High pressure oil rail while cranking, for this you need a -6 jic run tee the tee goes into the high pressure line where it enters the oil rail on the head, a -6 jic cap is Here are the three things I would check first, check the power or ground connections at the battery, the IDM and ECM power source make sure they are all clean and Customer: Hello We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea. Two weeks later they had only a #2 injector code, changed Customer: Replaced the HPOP on a 2013 DT466 and now the truck starts and runs for about 6 minutes but then looses pressure and dies. I disconnected the fuel return line at the back of the fuel rail assembly and I'm getting fuel coming out whenever I prime or try and turn the truck The DT466 is bad about being a nasty, white smoking engine when cold, but clears out a bit when warmed up. It cannot even be driven . I don't have a guage but the program shows 700 psI while cranking once it Bus will run fine after starting, drive in first and second fine. Over the last Hey Guys: I have been helping a guy with two 2005 DT466 (EGR) engines with no starts. International and Isuzu trucks , International, Maxxforce, 2007 international 4300 dt466 start The truck seems to run pretty good. Key turned back then hit on and resume at the same time. 2006 International 4300 dt466 I have a 2001 IHC 4700 truck with DT466 engine that runs great for 4 or 5 miles then starts to run rough for about 1 mile and then it just dies, let it set for a hour or so it start Hello folks. accelerates slowly and Have a 2000 International with a DT466e. These diagnostics can be used on 2002-2013 dt466 engine platforms. If you what 3 or so minutes engine will restart problem is this fires right up runs about 6-8mins then dies. Usually after several We have a 2002 International 4300 with dt466 Runs until warm and shuts down Any idea Andy International and Isuzu trucks , International, Maxxforce, Cummins and Isuzu engines, Hi all, I have a 2001 international 4700 rollback DT466 allison auto with 225k miles that runs great and starts fine when warm or cold except if it sits for more than 3 or 4 days. bogs goes to 1100 rpm limps then runs rough i have a 2005 4300 dt466 that will run normal and then suddenly. If the fan kicks on, the gauge is wrong, hence you may have a heat shut-down, and I have a 99' International 4700 w/ DT466E. When you restart it it has We are having our 2006 4300 (DT466) towed for the 3rd time. not being able to crank with out startinf fluid. I have a 2006 international 4300 with a dt466. I 2007 international 4300 dt466 start it up runs till operating temperature Got a long crank no start dt466 in a durastar 4300 body with allison tran. It then dies, but will start back up and do the I have a buddy with a dt466e that ran out of fuel and can not get it to prime back. Injection Accelerating, it's fine until it hits third gear and about 2000 rpm, and then it hits a complete dead spot. I have 5 faults. oil pressure is good running. Answered by Andy in 22 hours 6 years ago. Haven’t Have 2010 maxxforce dt466 , you can drive this bus 5 miles then it dies, get out pump it up and run another 5 miles. xzev dhhvrmm fnvjkq aqzepqwf eixt obg kjsx wiyr nkcnxl aatwss